Effect of Marble Powder Waste as Fine Aggregate Substitution in Rigid Pavement

Maria Sesi Nukar; M. Sa'dillah; Blima Oktaviastuti

doi:10.36055/fondasi.v13i2.28680

Effect of Marble Powder Waste as Fine Aggregate Substitution in Rigid Pavement

Maria Sesi Nukar, M. Sa'dillah, Blima Oktaviastuti

Abstract

The demand for construction materials, particularly for pavement construction, continues to rise, leading to a reduction in available material resources. To address this, an alternative approach has been developed by utilizing marble powder waste as a partial substitute for fine aggregate in rigid pavement construction. This study employs a quantitative, experimental research design aimed at determining the compressive and flexural strength of concrete when marble powder is used as a partial replacement. The compressive strength tests involved varying the marble powder content at 0%, 15%, 25%, and 35%, with assessments at both 7 and 28 days, targeting a planned concrete quality of fc' 21,7 MPa. The compressive strength values at 7 days for each variation are as follows: 0% (13,06 MPa), 15% (13,98 MPa), 25% (15,99 MPa), and 35% (14,10 MPa). At 28 days, the compressive strength results were 0% (22,00 MPa), 15% (23,79 MPa), 25% (16,97 MPa), and 35% (15,67 MPa). For the flexural strength tests, marble powder was substituted at levels of 0%, 15%, 25%, and 35% in concrete specimens measuring 12x50x120cm, with the load applied at 28 days. The maximum load recorded for each variation was 0% (4300 kg), 15% (3200 kg), 25% (4000 kg), and 35% (2500 kg). The average deflection observed was 0% (3,93mm), 15% (2,60mm), 25% (4,26mm), and 35% (2,37mm).

Keywords

Rigid Pavement, Waste, Marble Powder, Compressive Strength, Flexural Strength

Full Text:

PDF

References

A. S. Andreani, T. H. V R., B. F. Seki, And N. Farrah, “The Impact Of Waste Marble Powder As A Partial Alternative Material For Cement,” J. Sains Mater. Indones., Vol. 26, No. 1, Pp. 81–91, 2024, Doi: 10.55981/Jsmi.2024.4569.

F. Juwita, D. Nurafni, S. Subekti, C. Sujatmiko, And M. A. Silova, “Evaluasi Tebal Perkerasan Kaku Pada Jalan Provinsi Berdasarkan Manual Desain Perkerasan (Mdp) 2017 (Studi Kasus : Ruas Jalan Padang Ratu - Kalirejo),” Tek. Sains J. Ilmu Tek., Vol. 8, No. 1, Pp. 30–43, 2023, Doi: Https://Doi.Org/10.24967/Teksis.V8i1.2137.

R. Ardiansyah And T. Sudibyo, “Analisis Perencanaan Tebal Perkerasan Kaku Lajur Pengganti Pada Proyek Pembangunan Jalan Tol Jakarta-Cikampek Ii Elevated,” J. Tek. Sipil Dan Lingkung., Vol. 5, No. 1, Pp. 17–30, 2020, Doi: Https://Doi.Org/10.29244/Jsil.5.1.17-30.

E. A. Khan Et Al., “Utilization Of Waste Marble Powder As Partial Replacement Of Cement In Engineered Cementitious Composite,” Cogent Eng., Vol. 10, No. 1, P. 2243749, 2023, Doi: 10.1080/23311916.2023.2243749.

Y. O. Özkılıç Et Al., “Optimum Usage Of Waste Marble Powder To Reduce Use Of Cement Toward Eco-Friendly Concrete,” J. Mater. Res. Technol., Vol. 25, Pp. 4799–4819, 2023, Doi: Https://Doi.Org/10.1016/J.Jmrt.2023.06.126.

B. Oktaviastuti, G. D. Pandulu, And E. Lusyana, “Kuat Tekan Beton Geopolymer Berbahan Dasar Abu Terbang (Fly Ash) Sebagai Alternatif Perkerasan Kaku Di Daerah Pesisir,” Reka Buana J. Ilm. Tek. Sipil Dan Tek. Kim., Vol. 6, No. 1, Pp. 78–87, 2021, Doi: Https://Doi.Org/10.33366/Rekabua Na.V6i1.2271.

B. Oktaviastuti, A. Leliana, And P. D. Rahma, “Beton Geopolimer Sebagai Alternatif Perkerasan Kaku ( Rigid Pavement ) Ramah Lingkungan,” Vol. 2, No. 1999, Pp. 1–5, 2019, [Online]. Available: Https://Pro.Unitri.Ac.Id/Index.Php/Sentikuin/Article/View/151.

B. Oktaviastuti And Yurnalisdel, “Studi Kuat Tekan Beton Geopolymer Dengan Fly Ash Sebagai Perkerasan Kaku Di Pesisir Pantai,” J. Fondasi, Vol. 9, No. 2, Pp. 201–214, 2020, [Online]. Available: Https://Jurnal.Untirta.Ac.Id/Index.Php/Jft/Article/View/8515/6509.

Y. Rusdianto And M. Munir, “Penggunaan Limbah Marmer Sebagai Filler Terhadap Absorbsi, Kuat Tekan Dan Modulus Elastisitaas Pada Beton,” Media Tek. Sipil, Vol. 13, No. 1, Pp. 99–108, 2015, Doi: Https://Doi.Org/10.22219/Jmts.V13i1.2549.

A. Gecong, B. Dharmawan, And A. Novraji, “Pengaruh Limbah Marmer Sebagai Filler Pada Campuran Beton Aspal Terhadap Pengujian Modulus Resilien,” J. Tek. Sipil Macca, Vol. 4, Pp. 125–137, 2019, Doi: 10.33096/Jtsm.V4i2.368.

A. Amal And W. Saputra, “Pemanfaatan Limbah Abu Marmer Sebagai Filler Terhadap Karakteristik Marshall Pada Campuran Lapis Tipis Aspal Pasir (Latasir) B,” J. Media Tek. Sipil, Vol. 16, 2019, Doi: 10.22219/Jmts.V16i2.6744.

N. M. Sugita, “Tentang Desa Besole Yang Bikin Tulungagung Dijuluki Kota Marmer,” Detikjatim.Com, Nov. 2023.

R. Nastalia, A. Naibaho, And S. Riyanto, “Analisis Kuat Tekan Dan Tarik Beton Normal Menggunakan Serbuk Limbah Gergaji Marmer Sebagai Substitusi Semen,” J. Online Skripsi Manaj. Rekayasa Konstr., Vol. 4, No. 1, Pp. 160–165, 2023, Doi: Https://Doi.Org/10.33795/Josmrk.V4i1.1202.

L. Asif And W. Malik, “Effect Of Marble Powder On Concrete: A Review,” In 2nd International Conference On Engineering, Natural And Social Sciences (Icensos), 2023, Pp. 166–171, [Online]. Available: Https://Www.Icensos.Com/.

C. Aditya, D. Irawan, And S. Silviana, “Implementation Of Marble Waste As Aggregate Material Rigid Pavement,” Eureka Phys. Eng., No. 4, Pp. 76–88, 2021, Doi: 10.21303/2461-4262.2021.001932.

Sugiyono, Metode Penelitian Pendidikan Pendekatan Kuantitatif, Kualitatif, Dan R&D. Bandung, 2019.

J. W. Creswell, Research Design: Pendekatan Metode Kualitatif, Kuantitatif, Dan Campuran. Yogyakarta: Pustaka Pelajar, 2016.

M. Y. E. S. Hartanto Dwi, Hasanuddin Akhmad, “Pemanfaatan Limbah Batu Marmer Sebagai Agregat Kasar Pada Campuran Beton Perkerasan Kaku Yang Menggunakan Bahan Tambah Abu Sekam Padi,” Reka Buana, Vol. 7, Pp. 1–16, 2022.

D. D. K. Wijayanti And A. Wardhono, “Pengaruh Subtitusi Limbah Marmer Terhadap Nilai Kuat Tekan Dry Geopolymer Mortar Metode Wet Mixing Berbahan Dasar Abu Terbang Dan Naoh 12 M,” Rekats Rekayasa Tek. Sipil Univ. Negeri Surabaya, Vol. 9, No. 2, 2021, [Online]. Https://Ejournal.Unesa.Ac.Id/Index.Php/Rekayasa-Teknik-Sipil/Article/View/39021.

D. Fitriani, R. D. Kusdian, And B. A. Bakar, “Kajian Kuat Tekan Beton Substitusi Agregat Halus Dari Limbah Pemotongan Batu Marmer Dan Agregat Kasar Dari Limbah Pemotongan Batu Kapur,” Simteks Sist. Infrastruktur Tek. Sipil, Vol. 1, No. 1, Pp. 89–98, 2021, Doi: Https://Doi.Org/10.32897/Simteks.V1i1.808.

A. Safari And A. A. Setiawan, “Pemanfaatan Limbah Batu Marmer Sebagai Substitusi Parsial Agregat Kasar Pada Campuran Beton Terhadap Kuat Tekan Beton,” J. Ilm. Din. Rekayasa, Vol. 19, No. 2, Pp. 141–146, 2023, Doi: Http://Dx.Doi.Org/10.20884/1.Dr.2023.19.2.1498.

Budianto, Dedi Cahyono, And Johan, “Pengaruh Pemanfaatan Limbah Marmer Sebagai Subtitusi Semen The Effect Of Utilization Of Marble Waste As Subtitution Of Cement In Mixed Paving Block With 3 %, 8 % And 12 % Percentage,” Pp. 3–5.

A. D. Lestari, “Pengujian Kuat Tekan Pada Beton Dengan Limbah Marmer Sebagai Subtitusi Agregat Kasar,” Reka Buana J. Ilm. Tek. Sipil Dan Tek. Kim., Vol. 6, No. 1, Pp. 61–69, 2021, Doi: Https://Doi.Org/10.33366/Rekabuana.V6i1.2263.

A. Abrori And D. B. Fariadi, “Studi Penelitian Pengaruh Penggunaan Limbah Marble Sebagai Pengganti Bahan Pengikat Terhadap Kuat Lentur Beton,” Semin. Keinsinyuran Progr. Stud. Progr. Profesi Ins., Pp. 681–689, 2021, Doi: 10.22219/Skpsppi.V2i1.4374.

J. E. Mercy, F. Phengkarsa, And S. R. Tonapa, “Pengaruh Silica Fume Dan Pecahan Batu Marmer Sebagai Bahan Subtitusi Pada Campuran Beton,” Paulus Civ. Eng. J., Vol. 5, No. 1, Pp. 29–39, 2024, [Online]. Https://Ojs.Ukipaulus.Ac.Id/Index.Php/Pcej/Article/View/67.

DOI: http://dx.doi.org/10.36055/fondasi.v13i2.28680