Effect of Wheat Flour Concentration on Physicochemical and Sensory Properties of Cilembu Yam Chicken Nugget

Jennifer Elizabeth, Chatarina Yayuk Trisnawati, Anita Maya Sutedja

Abstract


Cilembu yam is a yellow or orange yam that is abundantly available that is still minimally utilized in Indonesia. One alternative to diversify the utilization of cilembu yam is processing it into cilembu yam chicken nuggets. The 50% substitution of chicken meat with cilembu yam produces nuggets with a more attractive color and the taste of chicken is still felt and the sweetness is not prominent but the texture of the nuggets becomes too soft so it requires the addition of wheat flour as a filler and binder. The objective of this study was to determine the effect of wheat flour concentration on the physicochemical and sensory characteristics of cilembu yam-chicken nuggets. The research design used a single-factor randomized group design with four replications. The concentration of wheat flour added was 5%, 10%, 15%, 20%, 25%, and 30%. Data were analyzed with Analysis of Variance with α=5% then followed by the Duncan’s Multiple Range Test with α=5%. The results showed that as the concentration of wheat flour increased, the water holding capacity of the nugget batter as well as the hardness and toughness of the fried cilembu yam chicken nugget increased while the moisture content and juiceness decreased. Preference of bite ability increased up to 15% wheat flour concentration and was not significantly different from 20%. The use of wheat flour concentration up to 20% increased the preference of springiness but decreased the preference of juiceness to an acceptable level.


Keywords


cilembu yam chicken nugget, wheat flour, physicochemical properties, sensory properties

Full Text:

PDF

References


Ariwibowo, F. & Ayuningtyas, P. R. (2023). Daya terima formulasi penambahan sayur (wortel, bayam, dan brokoli) pada nugget ayam (NUSA). Media Gizi Kesmas, 12(1), 53-58. https://doi.org/10.20473/mgk.v12i1.2023.53-58

Brigita, E. (2021). Kajian Pustaka: Pemanfaatan Umbi-Umbian Sebagai Bahan Baku Flakes. Laporan Tugas Akhir, Fakultas Teknologi Pangan, Universitas Katolik Soegijapranata.

Cheung, J. K. T. (2019). Optimasi Konsentrasi Karagenan, Konsentrasi Garam, dan pH untuk Membentuk Gel dari Larva Ulat Hongkong yang Menyerupai Gel Daging Sapi. Skripsi, Fakultas Teknologi Pertanian, Universitas Katolik Soegijapranata Semarang.

Fahrullah, Bulkaini, Kisworo, D., Wulandani, B. R. D., Yulianto, W., Haryanto, Noersidiq, A., & Maslami, V. (2023). Inovasi pembuatan nugget kombinasi ayam dan jagung untuk peningkatan flavour di Desa Banjur, Kabupaten Lombok Barat. Jurnal Pengabdian Magister Pendidikan IPA, 6(3), 561-565. https://doi.org/10.29303/jpmpi.v6i3.4920

Fitriani, S., Yusmarini, Riftyan, E., Saputra, & Rohmah, M. C. (2023). Karakteristik dan profil pasta pati sagu modifikasi pragelatinisasi pada suhu yang berbeda. Jurnal Teknologi Hasil Pertanian, 16(2), 104-115. https://doi.org/10.20961/jthp.v16i2.56057

Hairunnissa, L., Sari, A. K., Jati, I. S., Shalihah, I. M., Akifah, S. D., Izzati, A. N., Putri, N. A., & Najah, Z. (2021). Chemical and organoleptic characteristics of chicken nugget based on composite flour from MOCAF, brown rice and corn starch. Food ScienTech Journal, 3(1), 76-83. https://doi.org/10.33512/fsj.v3i1.12224

Jamaly, S. I., Hashem, M. A., Akhter, S., & Hossain, M. A. (2017). Wheat flour as dietary fiber on fresh and preserved beef meatballs. Journal of Animal Science, 46(1), 35-43. https://doi.org/10.3329/bjas.v46i1.32175

Lestari, J., Rozali, Z. F., & Zaidiyah. (2023). Kajian penambahan bayam (Amaranthus sp.) terhadap nilai sensori nugget ayam. Jurnal Ilmiah Mahasiswa Pertanian, 8(4), 524-532. https://doi.org/10.17969/jimfp.v8i4.27358.

Li, R., Carpenter, J. A., & Cheney, R. (1998). Sensory and instrumental properties of smoked sausage made with mechanically separated poultry (MSP) meat and wheat protein. Journal of Food Science, 63(5), 1-7. https://doi.org/10.12691/jfnr-4-4-4

Mahmudatussa’adah, A. (2014). Komposisi kimia ubi jalar (Ipoema batatas L.) cilembu pada berbagai waktu simpan sebagai bahan baku gula cair. Pangan, 23(1), 53–64. https://doi.org/10.33964/jp.v23i1.51

Nwosisi, S., Nandwani, D., & Ravi, R. (2019). Texture profile analysis (TPA) of organic sweetpotato (Ipoema batatas) cultivar as affected by different processing methods. Journal of Microbiology, Biotechnology, and Food Sciences, 8(6), 1254-1259. https://doi.org/ 10.15414/jmbfs.2019.8.6.1254-1259

Peleg, M. (2019). The instrumental texture profile analysis revisited. Journal of Texture Studies, 50(5), 1-7. https://doi.org/10.1111/jtxs.12392

Pramono, Y. B., Katherinatama, A., & Ardan, G. S. (2020). Pengawasan Mutu Sistem First In First Out (FIFO) pada Tepung Terigu. Semarang: UNDIP Press.

Sekretariat Jenderal Kementerian Pertanian. (2022). Statistik konsumsi pangan tahun 2022.https://satudata.pertanian.go.id/assets/docs/publikasi/Buku_Statistik_Konsumsi_2022.pdf. Date accessed 14 November 2024.

Soegijono, G. V. (2019). Pengaruh Perbedaan Konsentrasi Terigu terhadap Karakteristik Fisikokimia dan Organoleptik Nugget Ayam dengan Penambahan Nangka Muda. Skripsi, Fakultas Teknologi Pertanian, Universitas Katolik Widya Mandala Surabaya.

Suseno, T. I. P., Surjoseputro, S., & Fransisca, I. M. (2007). Pengaruh jenis bagian daging babi dan penambahan tepung terigu terhadap sifat fisikokimiawi pork nugget. Jurnal Teknologi Pangan dan Gizi, 6(2), 15-25. https://doi.org/10.33508/jtpg.v6i2.143

Syahbanu, F., Napitupulu, F. I., Septiana, S., & Aliyah, N. F. (2023). Struktur pati beras (Oryza sativa L.) dan mekanisme perubahannya pada fenomena gelatinisasi dan retrogradasi. Agrointek, 17(4), 755-767. https://doi.org/10.21107/agrointek.v17i4.15315

Szmańko, T., Lesiów, T., & Górecka, J. (2021). The water-holding capacity of meat: A reference analytical method. Food Chemistry, 357. https://doi.org/10.1016/j.foodchem.2021.129727

Wang, C. H., & Damodaran, S. (1991). Thermal gelation of globular proteins: influence of protein conformation on gel strength. Journal of Agricultural and Food Chemistry, 39(3), 433-438. https://doi.org/10.12691/jfnr-3-3-4s

Widjaja, C. (2004). Kajian Pengaruh Proporsi Tepung Terigu dan Tepung Ganyong terhadap Sifat Fisikokimiawi dan Organoleptik Beef Nugget. Skripsi, Fakultas Teknologi Pertanian, Universitas Katolik Widya Mandala Surabaya.

Zhang, Y., Brouwer, R., Sala, G., Scholten, E., & Stieger, M. (2024). Exploring relationship between juiciness perception, food and bolus properties of plant-based meat analogue and beef patties. Food Hydrocolloids, 147(B), 1-13. https://doi.org/10.1016/j.foodhyd.2023.109443




DOI: http://dx.doi.org/10.33512/fsj.v7i1.30982

Refbacks

  • There are currently no refbacks.


Creative Commons License
This work is licensed under a Creative Commons Attribution-ShareAlike 4.0 International License.